Product ID:E-57 EMULSIFIER
MSDS Date:01/01/1995
FSC:6850
NIIN:01-263-8222
Kit Part:Y
MSDS Number: BGTMY

Emergency Phone: 310-450-1111/800-424-9300(CHEMTREC)

Info Phone: 310-450-1111

Cage: 98733

Telephone: 310-450-1111/FAX 310452-4046

Cage: 98733

MINERAL OIL, PETROLEUM DISTILLATE/PETROLEUM HYDROCARBON

CAS: 64741-96-4

RTECS: PY8040000

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
TRACT. ACUTE- EYES:PRESUMED NON-IRRITATING. SKIN:SLIGHTLY
IRRITATING. INHALATION:VAPORS OR MIST MAY CAUSE MILD IRRITTION OF
UPPER RESPIRATORY TRACT. ORAL:MAY CAUS E VOMITING. ASPIRATION
HAZARD. CHRONIC-UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
TO THE EFFECTS OF THIS PRODUCT.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. GET MEDICAL ATTENTION.

Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, SAND, FOAM/DRY CHEMICAL.
DO NOT USE DIRECT STREAM OF WATER.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. VENTILATE AREA.
CONTAIN AND PICK UP SPILL WITH NON-FLAMMABLE ABSORBENT SUCH AS
SAND, EARTH, VERMICULITE. PREVENT LIQUID FROM ENTERING SEWERS OR
WATERWAYS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL PLACE AWAY FROM FLAMES
AND OXIDIZING MATERIALS.
Other Precautions:WASH THOROUGHLY WITH SOAP AND WATER AFTER HANDLING
AND BEFORE EATING, DRINKING, SMOKING. KEEP OUT OF REACH OF
CHILDREN.

Respiratory Protection:NONE NORMALLY REQUIRED. IF TLV IS EXCEEDED OR
FOR SYMPTOMS OF OVER EXPOSURE, WEAR NIOSH-APPROVED ORGANIC VAPOR
RESPIRATOR OR AIR-PURIFYING RESPIRATOR. IN EMERGENCY, WEAR A
NIOSH-APPROVED POSITIVE-PRES SURE SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:LOCAL EXHAUST IS RECOMMENDED FOR CONFINED AREAS. GENERAL
MECHANICAL VENTILATION IS ADEQUATE FOR NORMAL USE.
Protective Gloves:RUBBER TO PREVENT CONTACT
Eye Protection:SAFETY GLASSES WITH SIDE SHIELD
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
NSN FOR KIT OF OF TYPE 1, METHOD B, LEVEL 3 OF MIL-I-25135.PER
QPL-25135-15, FP-95A(M) PENETRANT AND E-57 EMULSIFIER ARE THE TWO
PARTS OF THE SET. THIS ENTRY DESCRIBES E-57 EMULSIFIER. SEE PNIND A
FOR THE PENETRANT DATA. KEY1:N1

HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:400F,204C
Spec Gravity:0.92 (ABOUT)
Solubility in Water:EMULSIFIABLE
Appearance and Odor:PINK OILY LIQUID, SLIGHT HYDROCARBON ODOR

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:OPEN FLAME AND EXTREME HEAT
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, CARBON
DIOXIDE AND UNIDENTIFIED ORGANIC COMPOUNDS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.